Jump to content

Zvezda (ISS module)

From Wikipedia, the free encyclopedia
"DOS-8" redirects here. For other uses, see DOS 8.

Zvezda
Zvezda as seen by Space Shuttle Atlantis during STS-106
Module statistics
COSPAR ID2000-037A
Part ofInternational Space Station
Launch date12 July 2000, 04:56 UTC
Launch vehicleProton-K
Docked26 July 2000, 01:45 UTC (Zarya aft)
Mass20,320 kg (44,800 lb)
Length13.1 m (43 ft)
Width29.7 m (97 ft)
Diameter4.35 m (14.3 ft)
Pressurised volume
  • 75 m3 (2,600 cu ft)
  • Habitable: 46.7 m3 (1,650 cu ft)
References: [1][2][3][4][5][6]
Configuration

On-orbit configuration of the Zvezda service module
Zvezda heads into orbit aboard a Proton launch vehicle on 12 July 2000.
Expedition 43 crew celebrate a birthday in Zvezda module, 2015.

Zvezda (Russian: Звезда, lit. 'star'), also known as the Zvezda Service Module, is a module of the International Space Station (ISS). It was the third module launched to the station, and provided all of the station's life support systems, some of which are supplemented in the US Orbital Segment (USOS), as well as living quarters for two crew members. It is the structural and functional center of the Russian Orbital Segment (ROS), which is the Russian part of the ISS. Crew assemble here to deal with emergencies on the station.[7][8][9]

The module was manufactured in the USSR by Energia, with major sub-contracting work by GKNPTs Khrunichev.[10] Zvezda was launched on a Proton launch vehicle on 12 July 2000, and docked with the Zarya module on 26 July 2000 at 01:45 UTC. It is a descendant of the Salyut programme's DOS spacecraft, leading to the alternate name, DOS-8.

Origins

[edit]
Main article: Mir-2

The basic structural frame of Zvezda, known as "DOS-8", was initially built in the mid-1980s to be the core of the Mir-2 space station. This means that Zvezda is similar in layout to the core module (DOS-7) of the Mir space station. It was in fact labeled as Mir-2 for quite some time in the factory. Its design lineage thus extends back to the original Salyut stations. The space frame was completed in February 1985 and major internal equipment was installed by October 1986.

The Mir-2 space station was redesigned after the failure of the Polyus orbital weapons platform core module to reach orbit. Zvezda is around 1⁄4 the size of Polyus, and has no armaments.

Design

[edit]

Zvezda consists of the cylindrical "Work Compartment" where the crews work and live (and which makes up the bulk of the module's volume), the small spherical "Transfer Compartment" located at the front (with three docking ports), and at the aft end the cylindrical "Transfer Chamber" (with one docking port) which is surrounded by the unpressurized "Assembly Compartment" – this gives Zvezda four docking ports in total.[10] The component weighs about 18,051 kg (39,796 lb) and has a length of 13.1 m (43 ft). The solar panels extend 29.7 m (97 ft).

The "Transfer Compartment" attaches to the Zarya module, and has docking ports intended for the Science Power Platform (SPP) and the Universal Docking Module (UDM). As in the early days of Mir, the transfer compartment provides a suitable EVA airlock where spacewalkers in Orlan space suits removed a hatch after closing a few that connected the compartment to the rest of the station. It was used only during Expedition 2, where Yury Usachov and James Voss put a docking cone on the nadir port. The lower port connects to Pirs and the top port connects to Poisk. Eventually, the plan for Pirs was for it to be deorbited on 23 July 2021 and replaced by Nauka (Multipurpose Laboratory Module) docking on 29 July 2021.

Sprouts in the BIO-5 Rasteniya-2/Lada-2 (Plants-2) experiment aboard Zvezda[11]

The "Assembly Compartment" holds external equipment such as thrusters, thermometers, antennas, and propellant tanks. The large movable "Lira satellite communications antenna" is located on the Zvezda service module near the aft or rear of the International Space Station on this Assembly Compartment.[12] The "Transfer Chamber" is equipped with automatic docking equipment and is used to service Soyuz and Progress spacecraft.

Zvezda can support up to six crew [10] including separate sleeping quarters for two cosmonauts at a time.[10] It also has a NASA-provided Treadmill with Vibration Isolation Stabilization, a kitchen equipped with a refrigerator/freezer and a table, a bicycle for exercise, a toilet and other hygiene facilities. The crew's wastewater and condensation water pulled out of the cabin air is recycled. Zvezda has been criticised for being excessively noisy and the crew has been observed wearing earplugs inside it.

Zvezda has 14 windows.[10] There are two 22.5 cm (8.9 in) diameter windows, one in each of the two crew sleep compartments (windows No. 1 and 2), six 22.5 cm (8.9 in) diameter windows (No. 3, 4, 5, 6, 7 and 8) on the forward Transfer Compartment earth-facing floor, a 40 cm (16 in) diameter window in the main Working Compartment (No. 9), and one 7.5 cm (3.0 in) diameter window in the aft transfer compartment (No. 10). There are a further three 22.5 cm (8.9 in) diameter windows in the forward end of the forward transfer compartment (No. 12, 13 and 14), for observing approaching craft. Window No. 11 is unaccounted for in all available sources.

Zvezda also contains the Elektron system that electrolyzes condensed humidity and waste water to provide hydrogen and oxygen. The hydrogen is expelled into space and the oxygen (up to 5.13 kg per day is generated) is used for breathing air. The condensed water and the waste water can be used for drinking in an emergency, but ordinarily fresh water from Earth is used. The Elektron system has required significant maintenance work, having failed several times and requiring the crew to use the Solid Fuel Oxygen Generator canisters (also called "oxygen candles", which were the cause of a fire on Mir) when it has been broken for extended amounts of time. It also contains the Vozdukh, a system which removes carbon dioxide from the air based on the use of regenerable absorbers of carbon dioxide gas. Zvezda is also the home of the Lada Greenhouse, which is a test for growing plants in space.[13]

The Service Module has 16 small thrusters as well as two large 3,070-newton (690 lbf) S5.79 thrusters that are 2-axis mounted and can be gimballed 5°. The thrusters are pressure-fed from four tanks with a total capacity of 860 kg.[6] The oxidizer used for the propulsion system is dinitrogen tetroxide and the fuel is UDMH, the supply tanks being pressurised with nitrogen.[14] The two main engines on Zvezda can be used to raise the station's altitude. This was done on 25 April 2007. This was the first time the engines had been fired since Zvezda arrived in 2000.[15]

The Zvezda module inherited a limitation from its predecessor Mir and Salyut stations rooted in a Soviet spacecraft design philosophy favoring the permanent installation of critical hardware. This approach, while providing more internal living space by concealing systems behind closed panels, contrasts with the US Orbital Segment's (USOS) strategy of using easily replaceable 41.3-inch-wide (105 cm) International Standard Payload Racks. USOS modules, connected via the Common Berthing Mechanism (CBM), have 51-inch-wide (130 cm) hatches that accommodate the movement of these racks between modules and spacecraft. Consequently, broken or unfixable hardware on Zvezda remains permanently in place. A notable example is the pre-installed Elektron oxygen-generating system, which required frequent repairs by cosmonauts due to the inability to replace it. Zvezda's 78.74-centimetre-wide (31.00 in) hatch and the lack of available replacement Elektron units hindered the replacement process. The discontinuation of Elektron production further exacerbated this issue. In October 2020, the Elektron system malfunctioned again, leading to its deactivation.[16][17][18][19][20]

Connection to the ISS

[edit]
Progress docked to Zvezda (aft view)

The rocket used for launch to the ISS carried advertising; it was emblazoned with the logo of Pizza Hut restaurants,[21][22][23] for which they are reported to have paid more than US$1 million.[24] The money helped support Khrunichev State Research and Production Space Center and the Russian advertising agencies that orchestrated the event.[25]

Management and integration of the Service Module into the International Space Station began in 1991. Structural construction was performed by RKK Energia, then handed over to the Khrunichev Design Bureau for final outfitting. Joint reviews between the Russian Space Agency (Roscosmos) and the NASA ISS Program Office monitored construction, solved language and security concerns and ensured flight readiness and crew training. Several years of delay were encountered due to funding constraints between Roscosmos and RKK Energia requiring repeated delays in First Element Launch.

On 26 July 2000, Zvezda became the third component of the ISS when it docked at the aft port of Zarya. (The U.S. Unity module had already been attached to Zarya). Later in July, the computers aboard Zarya handed over ISS commanding functions to computers on Zvezda.[26]

On 11 September 2000, two members of the STS-106 Space Shuttle crew completed final connections between Zvezda and Zarya; during a 6-hour, 14 minute EVA, astronaut Ed Lu and cosmonaut Yuri Malenchenko connected nine cables between Zvezda and Zarya, including four power cables, four video and data cables and a fiber-optic telemetry cable.[27] The next day, STS-106 crew members floated into Zvezda for the first time, at 05:20 UTC on 12 September 2000.[28]

Zvezda provided early living quarters, a life support system, a communication system (Zvezda introduced a 10 Mbit/s Ethernet network to the ISS [29]), electrical power distribution, a data processing system, a flight control system, and a propulsion system. These quarters and some, but not all, systems have since been supplemented by additional ISS components.

Launch risks

[edit]

Due to Russian financial problems, Zvezda was launched with no backup and no insurance. Due to this risk, NASA had constructed an Interim Control Module (ICM) in case it was delayed significantly or destroyed on launch.[citation needed]

Air leaks

[edit]

Since September 2019, the Zvezda module has been experiencing a worsening air leak. The source appears to be microscopic structural cracks within the small transfer tunnel, known by the Russian acronym PrK, which connects Zvezda to the aft docking port typically used by Progress cargo spacecraft. Initially, the leak rate was minimal, less than 1 pound (0.45 kg) per day, but it has steadily increased, reaching 3.7 pounds (1.7 kg) per day as of April 2024. While both NASA and Roscosmos suspect issues with welds, the exact cause of the leak remains unknown. NASA has classified the leaks as a high-risk threat to spaceflight activities, potentially leading to "catastrophic failure." However, Roscosmos says that it does not believe a catastrophic disintegration of the PrK is realistic, and has expressed confidence in their ability to monitor and manage the leak.[30][31][32]

As of November 2024, to mitigate the leak and the risk of a catastrophic failure the normal operating procedure is to keep the hatch leading to the PrK from Zvezda closed except when a spacecraft is being actively accessed. When the hatch leading to the PrK is opened, a hatch leading to the US Orbital Segment of the ISS is closed, which would contain a catastrophic failure and decompression to just the Russian Orbital Segment.[32]

Interior

[edit]
  • Zvezda's space toilet
    Zvezda's space toilet
  • Forward view of interior of Zvezda
    Forward view of interior of Zvezda
  • Part of the galley
    Part of the galley
Zvezda aft. Items in the image include a crucifix, two icons, a telephoto camera lens, a camera flash, a zoom camera lens, other camera lenses, laptop computers with music playback software, a picture of Konstantin Tsiolkovsky, external speakers for a laptop computer, a picture of Yuri Gagarin, a Russian flag, a spaceplane model, a picture of Saint Petersburg, a fluorescent light fitting, several crew patches, and an oscillimeter (combined oscilloscope and multimeter).

Crew

[edit]
  • Crewmembers celebrating Christmas in Zvezda
    Crewmembers celebrating Christmas in Zvezda
  • View of one of the Zvezda crew quarters
    View of one of the Zvezda crew quarters
  • Cosmonaut in Zvezda, November 2000.
    Cosmonaut in Zvezda, November 2000.
  • Expedition 37 crew in Zvezda
    Expedition 37 crew in Zvezda
  • Roman Romanenko at a window in Zvezda
    Roman Romanenko at a window in Zvezda

Exterior

[edit]
  • Zvezda Service Module being manufactured at the Khrunichev factory
    Zvezda Service Module being manufactured at the Khrunichev factory
  • PMA-2, Unity Node 1, PMA-1, Zarya FGB, Zvezda Service Module, and Progress M1-3.
    PMA-2, Unity Node 1, PMA-1, Zarya FGB, Zvezda Service Module, and Progress M1-3.
  • The location of Zvezda in the Russian Orbital Segment
    The location of Zvezda in the Russian Orbital Segment
  • Sunrise in orbit overlooking Zvezda and its solar array
    Sunrise in orbit overlooking Zvezda and its solar array
  • Russian Orbital Segment windows
    Russian Orbital Segment windows
  • Zvezda nadir docking port where Pirs and Nauka were docked
    Zvezda nadir docking port where Pirs and Nauka were docked
  • Zenith docking port on Zvezda where Poisk had docked
    Zenith docking port on Zvezda where Poisk had docked

Dockings

[edit]
ATV-3 Edoardo Amaldi firing thrusters while approaching
Soyuz TMA-7 arrives at ISS. It was docked with Zvezda in 2006, but also spent time docked with Pirs and Zarya.
Zvezda docked with Progress M1-3

Aft port

Nadir

Zenith

Forward

References

[edit]
  1. ^ Public Domain This article incorporates text from this source, which is in the public domain: "The ISS to Date". NASA. 22 February 2007. Archived from the original on 3 June 2002. Retrieved 24 June 2007.
  2. ^ Public Domain This article incorporates text from this source, which is in the public domain: "International Space Station Status Report #06-7". NASA. 17 February 2006. Archived from the original on 15 June 2006. Retrieved 24 June 2007.
  3. ^ Public Domain This article incorporates text from this source, which is in the public domain: "NASA – Zvezda Service Module". NASA. 14 October 2006. Retrieved 10 July 2007.
  4. ^ "Служебный модуль 'Звезда'" ["Zvezda" service module] (in Russian). Yuri Gagarin Cosmonaut Training Center. Retrieved 11 June 2017.
  5. ^ "Zvezda Service Module". Khrunichev. Retrieved 11 June 2017.
  6. ^ a b "ISS Elements Service Module Zvezda". Spaceref. Retrieved 19 June 2020.
  7. ^ Public Domain This article incorporates text from this source, which is in the public domain: Williams, Sunita (presenter) (3 July 2015). Departing Space Station Commander Provides Tour of Orbital Laboratory (video). NASA. Event occurs at 17.46-18.26. Archived from the original on 22 December 2021. Retrieved 1 September 2019.
  8. ^ Roylance, Frank D. (11 November 2000). "Space station astronauts take shelter from solar radiation". The Baltimore Sun. Retrieved 1 September 2019.
  9. ^ Public Domain This article incorporates text from this source, which is in the public domain: Stofer, Kathryn (29 October 2013). "Tuesday/Wednesday Solar Punch". NASA. Retrieved 1 September 2019.
  10. ^ a b c d e "Service Module | RuSpace". suzymchale.com. Archived from the original on 21 September 2020. Retrieved 10 November 2020.
  11. ^ "Photo-iss006e45076". Spaceflight Insider. 22 June 2003. Archived from the original on 22 June 2003.
  12. ^ "COSMONAUTS PERFORM LONGEST RUSSIAN SPACEWALK TO UPGRADE HIGH-GAIN ANTENNA". 3 February 2018.
  13. ^ Public Domain This article incorporates text from this source, which is in the public domain: "Orbiting Agriculture". NASA. 20 October 2005. Retrieved 17 October 2020.
  14. ^ Anatoly Zak (18 June 2013). "Zvezda service module (SM)". Russian Space Web. Retrieved 8 April 2016.
  15. ^ Public Domain This article incorporates text from this source, which is in the public domain: "International Space Station Status Report: SS07-23". NASA.
  16. ^ Grand tour of the International Space Station with Drew and Luca | Single take, retrieved 30 July 2021
  17. ^ "Space station benefits from a wide opening". NBC News. Archived from the original on 2 March 2021. Retrieved 30 July 2021.
  18. ^ "Oxygen supply system deactivated in Russian ISS section due to malfunction". TASS. Retrieved 30 July 2021.
  19. ^ Zak, Anatoly. "A Rare Look at the Russian Side of the Space Station". Air & Space Magazine. Retrieved 30 July 2021.
  20. ^ "Oxygen problems plague space station". NBC News. Archived from the original on 21 January 2021. Retrieved 30 July 2021.
  21. ^ "Pizza Hut Puts Pie in the Sky with Rocket Logo". Space.com. 30 September 1999. Archived from the original on 14 January 2006. Retrieved 27 June 2006.
  22. ^ "Proton Set to Make Pizza Delivery to ISS". SpaceDaily. 8 July 2000. Retrieved 5 May 2013.
  23. ^ Geere, Duncan (2 November 2010). "The International Space Station is 10 today!". wired.co.uk. Wired. Retrieved 20 December 2014.
  24. ^ "THE MEDIA BUSINESS; Rocket to Carry Pizza Hut Logo". The New York Times. 1 October 1999. Retrieved 21 January 2009.
  25. ^ "Proton Set to Make Pizza Delivery to ISS". SpaceDaily. AFP. 8 July 2000.
  26. ^ Public Domain This article incorporates text from this source, which is in the public domain: "STS-106". NASA.
  27. ^ Public Domain This article incorporates text from this source, which is in the public domain: "STS-106 Report # 07". NASA.
  28. ^ Public Domain This article incorporates text from this source, which is in the public domain: "STS-106 Report # 10". NASA.
  29. ^ Public Domain This article incorporates text from this source, which is in the public domain: William Ivancic; Terry Bell; Dan Shell (April 2002). ISS and STS Commercial Off-The-Shelf Router Testing (PDF) (Report). NASA Technical Memo TM-2002-211310. Archived from the original (PDF) on 26 February 2009.
  30. ^ Berger, Eric (27 September 2024). "NASA confirms space station cracking a "highest" risk and consequence problem". Ars Technica. Retrieved 28 September 2024.
  31. ^ Berger, Eric (7 June 2024). "As leaks on the space station worsen, there's no clear plan to deal with them". Ars Technica. Retrieved 28 September 2024.
  32. ^ a b Clark, Stephen (18 November 2024). "The ISS has been leaking air for 5 years, and engineers still don't know why". Ars Technica. Retrieved 18 November 2024.
  33. ^ Public Domain This article incorporates text from this source, which is in the public domain: "Soyuz Relocation". NASA. Retrieved 29 August 2015.
  34. ^ a b Wright, Jerry (13 April 2015). "Soyuz Move Sets Stage for Arrival of New Crew". NASA.
[edit]
Retrieved from "https://en.wikipedia.org/w/index.php?title=Zvezda_(ISS_module)&oldid=1258321440"